Its compact modular design facilitates easy maintenance for inline repairs. It can be installed horizontal lor vertically without the need of any special tools.

Mueller Steam Specialty has literature available on its new easyopen basket strainer. It is designed to provide maximum straining protection for costly pipe line equipment and at the same time for quick, easy servicing. The quick-opening cover is secured with non-yoke type knobs. The cover and basket are O-ring sealed to minimize gasket replacement and service time. The basket O-ring seal also prevents particle bypass so that the strainers can trap particles as small as 5 microns when the appropriate wire mesh lining is specified.

This page titled 7.2: Filtration is shared under a CC BY-NC 3.0 license and was authored, remixed, and/or curated by Chris Schaller via source content that was edited to the style and standards of the LibreTexts platform.

Usually the funnel is a simple glass cone with a hole in the bottom, most often with a glass tube or stem leading from the hope to help guide the liquid to the vessel below. Sometimes, the funnel may have a flat bottom with holes in the bottom, or even a seemingly solid, but porous material. This last type is called a fritted funnel. The frit in the fritted funnel is porous material, just like filter paper, but it may be made of glass or plastic.

This 1 1/4 inch Y pattern reduced pressure zone backflow preventer assembly is designed to prevent the reverse flow of high hazard (toxic) fluids found in ...

Suppose you have a mixture that contains both a solid and a liquid. There are a couple of ways you could separate one from the other. Decanting is one way. In decanting, the liquid is sitting nicely on top of the solid, so you can just pour off the liquid and leave the solid behind. However, usually that leaves some of the liquid behind in the solid, so you haven't completely separated them.

20221222 — The pressure relief valve is used to protect the boiler drums from rupturing. The set pressure is determined to be some value less than the ...

One of the advantages of a fritted funnel is that it is easy to use a vacuum to speed up filtration. By reducing pressure on the bottom side of the frit, the atmospheric pressure above the frit helps to push the solution through the frit more quickly.

Note that filtration might allow isolation of either the solid phase or the liquid phase. In the former case, we would simply collect the solid that was held on the filter paper (we wouldn't use a filter agent like celite, which would contaminate the solid. The solid is usually allowed to dry before it is weighed and characterized.

88 Ductile Iron Full-Lug Butterfly Valve ; 8BFV · NoImage. ConnectionSize : 8 in. $473.10 / EA, 89 4.4 Call for Availability Branch Availability. Branch ...

In the laboratory, filtration can be done just as in the coffee filter. A filter paper is placed in a funnel and the mixture is poured in, and the liquid drips out under gravity. The liquid that drips through the filter paper is called the "filtrate".

Strainer Style: Strainer Assembly; Strainer Type: Y-strainers; Applications: General Purpose; Industrial; Water; Features: Self Cleaning; Media: Liquid; ...

The most common way to prevent this problem is to just put a piece of filter paper over the frit. The paper may prevent those particles from getting to the frit in the first place. The filter paper may get clogged in the same way, but you can just throw it out. Disposable filter paper may seem like a waste, but it is a much smaller waste than a disposable fritted funnel.

For really sticky situations, other filter aids include celite, a powder made from diatomaceous earth. A layer of celite is simple placed on top of the filter paper. Like the filter paper, the celite is disposable, but it protects the frit and allows the filtration to proceed more smoothly.

There are a couple of very basic purification methods that are used routinely in the laboratory, and that are actually key steps in other methods. Filtration is one of them.

The trouble is, frits can easily get clogged. Suppose there are particles suspended in the solution that are just small enough to get into the pores, but not small enough to move all the way through. They get stuck. Now we have a problem.

We offer a wide range of specialty-grade valves directly from the TRAC Regulator Company. Explore our TRAC pressure reducing and temperature regulating ...

The LibreTexts libraries are Powered by NICE CXone Expert and are supported by the Department of Education Open Textbook Pilot Project, the UC Davis Office of the Provost, the UC Davis Library, the California State University Affordable Learning Solutions Program, and Merlot. We also acknowledge previous National Science Foundation support under grant numbers 1246120, 1525057, and 1413739. Legal. Accessibility Statement For more information contact us at info@libretexts.org.

Length, 3.5000 ; Width, 3.5000 ; Volume, ~ ; PDW TS MFR DESC, 1/2 IN Brass Duo-Cloz Manual Washing Machine Shutoff Valve, Copper Ell Adapters For Solder or ...

Read Mueller Steam Specialty Introduces Basket Strainer — Literature Available in Pdf, Flash or Html5 edition of May 1984 Maritime Reporter

The Smart Boiler Control 294 provides central and indirect domestic hot water heating or volume domestic hot water heating by operating up to four boilers. This ...

Mueller Steam Specialty basket strainers are available from stock in cast iron, carbon steel, stainless steel and bronze. Standard basket material is stainless steel. Special materials, baskets and coatings are available on request.

We offer solutions in surface trench drain systems for all kind of needs in polymer concrete. Trench drains, sump units, gratings and accessories.

Filtration is a more thorough way of separating a solid from a liquid. The most familiar example might be a coffee maker. A coffee maker filters coffee from the ground coffee beans. The coffee falls through a filter paper, powered by gravity, and the coffee grounds remain on top of the filter paper.

If we are interested in the liquid, we might have more work to do. Maybe the liquid is pure, in which case we are finished. If it is a solution, we may wish to evaporate the solvent so that we could isolate the solute that we want.

Filtration relies on a porous material. In a porous material, there are pores or openings in the material that will allow small molecules pass through. You can think of the pores as tunnels. Small molecules, such as water and the organic molecules responsible for the properties of coffee, can easily move through the pores in the filter paper. Other materials, such as coffee grounds, cannot.

A temperature actuated mixing valve that mixes hot water with cold to deliver tempered water at a controlled temperature to 120°F (49°C) maximum.